Pma/510(k) # k142688.(b)(4).Exemption number: e2016031 (b)(4).Lab evaluation : 1 x echo-hd-25-c was returned to cirl for evaluation.Initial lab (b)(6) 2018: upon evaluation the following was noted the device was returned in original packaging.There was no stylet returned.It was difficult to retract the needle back into sheath after it was advanced.The bend in the needle was approximately 3.7mm from the tip.There were no cracks noted at the thumbscrews or the mlla.Follow up lab (b)(6) 2018: a stylet was unable to be passed through the device as it was bent during removal in lab so saline was passed down through the sheath to ensure it was not blocked with matter and the device was flushed and no matter was present.The customer complaint is considered to be confirmed as the failure was verified in the lab as the needle was bent.A definitive root cause for the customer complaint could not be determined as the exact operational conditions are unknown, possible causes may be due to user error as the stylet was not in place when advancing into target site.Prior to distribution, all echo-hd-25-c devices are subjected to functional checks and visual inspection to ensure device integrity.These inspections and functional checks are outlined in internal procedures in place at cirl.The notes section of the instructions for use, ifu0077-4, which accompanies this device instructs the user to: "visually inspect with particular attention to kinks, bends and breaks.If an abnormality is detected that would prohibit proper working condition, do not use".On review of the information provided, there is no viable evidence to suggest that the user did not follow the instructions for use.A review of the manufacturing records for the echo-hd-25-c device of lot# c1386123 did not reveal any discrepancies which could have contributed to this occurrence.There is no evidence to suggest that this issue effects the entire lot # c1386123; upon review of complaints this failure mode has not occurred previously with this lot # c1386123.According to the information received no adverse effects to the patient have been reported as a result of this occurrence.A section of the device did not remain inside the patient¿s body.The patient did not require any additional procedures due to this occurrence complaints of this nature will continue to be monitored for potential emerging trends.
|