The reason for this revision surgery, the agent reported "(patient had a previous glenoid fracture and the surgeon had to come back to do a reverse total shoulder after the fracture healed)".The previous surgery and the surgery detailed in this event occurred 4 months and 1 week apart.This evaluation is limited in scope as the item associated with this investigation was not returned to djo surgical - austin for examination.The surgery was completed as intended and without incident.If additional information regarding the reported event is submitted at a future date, this investigation will be re-evaluated.There was no information submitted with this complaint about any patient activities, accidents, or medical contraindications that may have contributed to the reported event.There were no findings during this evaluation that indicate the reported device was defective.The surgeon performed this procedure to remedy the patient's condition.No further action is deemed necessary.A review of the device history record (dhr) shows that the reported component used in the previous surgery, when released for use, met design and manufacturing requirements.There was a ncmr#50808 associated with the main part #520-42-216, altivate anatomic, neutral humeral head, 42x16, which documents that out of 10 parts lot, all parts were rejected due to multiple scratches along base of articulating surface.Later the rejected parts were reworked and retouched through spar.Out of 10 parts lot, 2 parts were rejected due to wavy reflection at center of sphere and unacceptable surface finish.Later the rejected parts were found with no defects and accepted after proper justification.The device was verified to have gone through an acceptable sterilization process and was within its expiration date at the time of the previous surgery.Customer complaint history of the reported device showed no present trends or on-going issues that are needing a review.(aravindraj) the root cause of this complaint was a revision surgery due to conversion of reverse total shoulder and fracture.No information was submitted with the complaint regarding pre-existing conditions of the patient or any activities the patient was involved in that may have contributed to the event.There are multiple factors that may also contribute to an event that are outside the control of djo surgical such as poor bone density, inadequate soft tissue support, patient activities or trauma.
|