Catalog Number 10220 |
Device Problem
Adverse Event Without Identified Device or Use Problem (2993)
|
Patient Problem
Hemolysis (1886)
|
Event Date 01/01/2019 |
Event Type
malfunction
|
Manufacturer Narrative
|
Lot number and expiry information are not available at this time.Per the article, "on further investigation, we found that there was an emergency change in brand of 5% human albumin solution from baxter ag (vienna, austria) to an indian brand seroalbumin (virchow biotech pvt.Ltd., andhra pradesh, india) due to the nonavailability of our routine supplies.Significant correlation was noticed between time of hemolysis and infusion of 5% albumin.Samples were taken from used normal saline, anticoagulant, and 5% albumin and were checked for quality and hemolysis test.About 5% albumin on centrifugation with red cells at 2000 rpm for 10 min showed pinkish discoloration.Biochemical analysis of 5% albumin solution showed sodium (na) concentration ¿ 22.5 mmol/l, potassium (k) ¿ 0, and chloride (cl) ¿ 6.0 mmol/l which confirmed our suspicion of hemolysis due to hyposmolality of albumin solution.Serum albumin levels were 4.0 g/dl which was less than 80% of total protein content (5.2 g/dl)." the case highlights the importance of root cause analysis of possible factors contributing to hemolysis or hemolytic reaction[1,2] during tpe [figure 1b].Quality control checks should be put on human albumin as well as other commercial solutions used in therapeutic apheresis procedures to ensure patient safety.Article citation: deepti, sachan, et.Al.2019.Hemolytic events during therapeutic plasma exchange: root cause analysis.Asian journal of transfusion science.Jan-jun; 13(1): 76¿78.2020https://www.Ncbi.Nlm.Nih.Gov/pm c/articles/pmc6580830/?report=printable investigation is in process.A follow-up report will be provided.The report indicates that the hemolysis was due to a change in albumin solution products.
|
|
Event Description
|
Per the article, hemolytic events during therapeutic plasma exchange: root cause analysis in the asian journal of transfusion science, a patient had hemolysis occur during a therapeutic exchange procedure (tpe): "the patient, a (b)(6) year-old male, was admitted with yellow phosphorus poisoning-induced acute liver failure and was undergoing 3rd cycle of tpe.The procedure was uneventful till 15 min; 400 ml normal saline was being given as initial replacement fluid and then switched to 5% albumin.Waste bag started showing reddish discoloration [figure 1a] and hemolysis alarm at approximate 150 ml of 5% human albumin solution (seroalbumin, india) infusion.The procedure was paused and was checked for possible causes of hemolysis due to patient, equipment, procedure, drugs, or replacement fluids.The procedure was aborted at whole blood (wb) processed 1023 ml and plasma removed 631 ml.The patient did not had any change in vitals or signs and symptoms, suggestive of hemolytic reaction.Post-tpe, the patient samples showed pink discoloration.There was no drop of hematocrit or laboratory picture of hemolysis.There was no plasma or any other blood component transfusion.There were no signs and symptoms or laboratory parameters suggestive of acute hemolytic reaction." the procedure was aborted.The patient was admitted in medical and liver transplant intensive care unit and had no previous clinical and laboratory features of hemolysis before starting the procedure.The report indicates that the hemolysis was due to a change in albumin solution products.Patient identifier and weight are not available at this time.The disposable set is not available for return because it was discarded by the customer.
|
|
Manufacturer Narrative
|
This report is being filed to provide additional information in e.1, h.6 and h.10.Investigation: the optia device serial number was not documented in the journal article, therefore a run data file (rdf) analysis could not be performed.The customer provided a photograph with the journal, which confirmed the waste bag displayed a reddish discoloration.The disposable lot number was not provided; therefore, a dhr search could not be conducted for this specific incident.All lots must meet acceptance criteria for release.Investigation is in process.A follow up report will be provided.
|
|
Manufacturer Narrative
|
Investigation is in process.A follow up report will be provided.
|
|
Manufacturer Narrative
|
This report is being filed to provide additional information in b.5 and h.10.Investigation: the customer provided a photograph with the journal, which confirmed the waste bag displayed a reddish discoloration.Per the article, "on further investigation, it was found that there was an emergency change in brand of 5% human albumin solution from baxter ag (vienna, austria) to an indian brand seroalbumin (virchow biotech pvt.Ltd., andhra pradesh, india) due to the nonavailability of our routine supplies.Significant correlation was noticed between time of hemolysis and infusion of 5% albumin.Laboratory investigation for hemolysis workup showed reddish discoloration in plasma color in both patients post procedure samples.Samples were taken from used normal saline, anticoagulant, and 5% albumin and were checked for quality and hemolysis test.About 5% albumin on centrifugation with red cells at 2000 rpm for 10 min showed pinkish discoloration.Biochemical analysis of 5% albumin solution showed sodium (na) concentration ¿ 22.5 mmol/l, potassium (k) ¿ 0, and chloride (cl) ¿ 6.0 mmol/l which confirmed our suspicion of hemolysis due to hyposmolality of albumin solution.Serum albumin levels were 4.0 g/dl which was less than 80% of total protein content (5.2 g/dl)." investigation is in process.A follow up report will be provided.
|
|
Event Description
|
Patient information is located on the aer tab.Patient ids and weights were unavailable.The author was contacted but has since left this hospital and no longer has access to the information.
|
|
Manufacturer Narrative
|
This report is being filed to provide additional information in h.6 and h.10.Investigation: based on terumobct internal medical review conclusion, it can be concluded that the hypoosmolality of the albumin solution used as fluid replacement likely caused hemolysis of the patient red blood cells.Root cause: based on the information in the journal article, the root cause of the hemolysis was due to a change in albumin solution products.The replacement albumin showed a failure of quality control with low sodium and albumin content in the bottle.Biochemical analysis of 5% albumin solution showed sodium (na) concentration ¿ 22.5 mmol/l, potassium (k) ¿ 0, and chloride (cl) ¿ 6.0 mmol/l which confirmed our suspicion of hemolysis due to hypoosmolality of albumin solution.Serum albumin levels were 4.0 g/dl which was less than 80% of total protein content (5.2 g/dl).
|
|
Search Alerts/Recalls
|
|