On 18th december, 2023 getinge became aware of an issue with one of surgical lights - volista access.Based on photographic evidence the designated complaint unit employee found that headlight cover was broken with missing particles.There was no injury reported, however, we decided to report the issue in abundance of caution as any parts falling off into sterile field or during procedure may cause contamination or serious injury.
|
The correction of b5 describe event and problem and d1 brand name deems required.This is based on the internal evaluation.Previous b5 describe event and problem: on 18th december, 2023 getinge became aware of an issue with one of surgical lights - volista access.Based on photographic evidence the designated complaint unit employee found that headlight cover was broken with missing particles.There was no injury reported, however, we decided to report the issue in abundance of caution as any parts falling off into sterile field or during procedure may cause contamination or serious injury.Corrected b5 describe event and problem: on 18th december, 2023 getinge became aware of an issue with one of surgical lights - volista access ii.Based on photographic evidence the designated complaint unit employee found that underside cover was broken with missing particles.There was no injury reported, however, we decided to report the issue in abundance of caution as any parts falling off into sterile field or during procedure may cause contamination or serious injury.Previous d1 brand name: volista access.Corrected d1 brand name: volista access ii.Initial reporter was hospital technician.Getinge became aware of an issue with one of surgical lights - volista access ii.Based on photographic evidence the designated complaint unit employee found that underside cover was broken with missing particles.There was no injury reported, however, we decided to report the issue in abundance of caution as any parts falling off into sterile field or during procedure may cause contamination or serious injury.Based on the information collected, it was established that when the event occurred, the surgical light did not meet its specification, since the cracked underside cover could be considered as technical deficiency, and in this way the device contributed to the event.Provided information does not indicate if upon the event occurrence, the device was or was not being used for patient treatment.When reviewing reportable events for this type of issues we were able to establish that the received incidents of cracked covers on volista surgical lights occur at a low ratio.We have been able to confirm that the investigated issue has never led to serious injury or worse, to our knowledge.As stated by the subject matter expert at maquet sas, the crack, starting at the edge of the underside fixing point located under the peripheral seal, was caused by a collisions or an inadapted cleaning protocol.The underside fixing point located under the peripheral seal is a retention zone, residues of cleaning agent can lead, by stagnation, to a loss of mechanical properties of plastic parts.During the design and the development, of the volista light head, several cleaning tests were carried out, the conclusion of the report cre 15-030 states that no damage was observed.To prevent any incident during the surgical procedure, the volista instruction for use ifu 01781 en19 mentions: to perform daily inspections checking that the underside is not damaged (page 39).The risk of collision and explains to pre position the device to avoid it (pages 60-64).How to clean and disinfect the light heads.This document includes some recommended products and some prohibited products (pages 89-90).The volista light head must be used according to the instructions for use.To prevent any degradation it is recommended to avoid collisions and to wipe the surfaces with a dry cloth to make sure that no liquid residue is left on the device after cleaning.Getinge shall continue to monitor for any further events of this nature and do not propose any action at this time.
|
On 18th december, 2023 getinge became aware of an issue with one of surgical lights - volista access ii.Based on photographic evidence the designated complaint unit employee found that underside cover was broken with missing particles.There was no injury reported, however, we decided to report the issue in abundance of caution as any parts falling off into sterile field or during procedure may cause contamination or serious injury.
|